1970 Occupational Health & Safety Act created the Occupational Safety and Health Administration (OSHA) and empowered OSHA to create and enforce workplace safety standards. Date of issue: 01/01/1982 Revision date: 10/24/2016 Supersedes: 10/26/2015 EN (English US) SDS ID: P-4798 1/10 Per the AAMI 10993-7 standard, “No exposure limits are set for ethylene glycol because risk assessment indicated that when EO residues are controlled, it is unlikely that biologically significant residues of EG would be present.”   The primary routes of human exposure to ethylene oxide are inhalation and ingestion, which may occur through occupational, consumer, or environmental exposure. Ethylene oxide, or EtO, is a gas at room temperature. Permissible exposure limits — 1910.1047 (c) (1) 8-hour time weighted average (TWA). Exposure limits and guidelines when using ethylene oxide have been set by a number of national agencies including the following: OSHA: Occupational and Safety Health Administration. Under the Clean Air Act, the EPA has set emission standards for 187 different toxic air pollutants, including ethylene oxide. It is obtainable mixed with carbon dioxide in the proportion of one part ETO to nine parts CO2 by weight or lt or 12 percent ETO with nonflammable halogenated hydrocarbon refrigerant gases. Geneva, World Health Organization (Environmental Health Criteria The permit limits total facility emissions of ethylene oxide to 150 pounds per year. Ethylene Oxide Vapor Monitor can be worn as a badge near the breathing zone to measure personal exposure, or placed in a room to measure area concentration. ��3�������R� `̊j��[�~ :� w���! Accordingly, at measured background levels of ethylene oxide, the EPA’s unit risk factor for lymphoid cancer (7.1E-03 per ppb, ADAF adjusted) would predict a population-weighted lymphoid cancer incidence rate of ≈3.7% (in the absence of any exogenous ethylene oxide ambient air exposure or other potential causes of lymphoid cancer). The hospital creates and maintains an inventory that identifies hazardous materials and waste used, stored, or generated using criteria consistent with applicable law and regulation (for example, the Environmental Protection Agency [EPA] and the Occupational Safety and Health Administration [OSHA]). Except as limited by paragraph (f) of this section, each employer shall, upon request, assure the access to each employee and designated representative to employee exposure records relevant to the employee. Inland Transport of Dangerous Goods Directive, Annex III ... Occupational exposure limits - Previous calls for comments and evidence; Occupational exposure limits – Consultations on OEL recommendation; <>stream Employees must be notified of their personal monitoring results within 15 days of when the monitoring report is available, and a copy of the monitoring records must be kept in each employee’s file. For example, the used and reported detection limit for ethylene oxide in EHEC is, according to the petitioner, … [b(1)]. Ethylene oxide . 2 0 obj OSHA Permissible Exposure Limit (PEL) : 1.0 ppm (8 Hr TWA) -Duties: Employers have a duty to provide a safe work environment and employees have a duty to work safely. Methods and observations that may be used to detect the presence or release of a hazardous chemical in the work area (such as monitoring conducted by the employer, continuous monitoring devices, visual appearance or odor of hazardous chemicals when being released, etc. Permissible Exposure Limit (PEL) for the amount of ethylene oxide in your workplace air. : United Kingdom Health & Safety Executive The deadline for meeting the requirements of the state permit is December 18, 2019. Also, if the posted results show that all areas and occupations are below the action level, employees will be encouraged to continue the safe practices that made this possible. It is not necessary to base the EtO alarm trigger specifically on the OSHA action level (0.5 ppm) or permissible exposure limits for 8 hours (1 ppm) or 15 minutes (5 ppm). %���� endstream The methods the employer will use to inform employees of the hazards of non-routine task, Trade secrets – information can be kept as trade secrets so long as safety information is not withheld and composition is made available in case of emergency. Ethylene Oxide may polymerize (self-react) violently. Ethylene oxide (also known as ETO or oxirane) is a flammable gas with a somewhat sweet odor. ETHYLENE OXIDE: ICSC: 0155: 1,2-Epoxyethane Oxirane Dimethylene oxide: July 2015: CAS #: 75-21-8: ... Explosive limits, vol% in air: 3-100 Octanol/water partition coefficient as log Pow: -0.3 EXPOSURE & HEALTH EFFECTS; Routes of exposure The substance can be absorbed into the body by inhalation and through the skin.   If EBX monitoring shows EtO levels exceeding the PEL or EL, corrective actions must be taken and documented, as required by OSHA. [i]. NIOSH Immediately Dangerous to Life and Health (IDLH), : American Conference of Government Industrial Hygienist, : Association for the Advancement of Medical Instrument, : United Kingdom Health & Safety Executive. The United States Environmental Protection Agency (the EPA) undertook a 10-year study on the potential dangers associated with exposure to ethylene oxide. ACGIH Threshold Limit Values TLV   hޜ�wTT��Ͻwz��0�z�.0��. : Association for the Advancement of Medical Instrument Ethylene oxide is produced in large volumes and is used to make other chemicals, especially ethylene glycol, a chemical used to make antifreeze and polyester. $�TH�;Ԉvq�B�0d`s�2�aŦlR/Ob g����FI�e��(�r�cU���Z��7�7�n�5�m^�;M���}j��x�_UA��$�P���h��p�$���x�G��ԛ��x2��~���S��p������X8P$�'��4M��Ƽ��O$���q�\R�+��*+H�e���Ն�P�!a1"�*��$9n�b�Ӷ���h�uQ e0�Xv��܃�����T��e[>��E� b?J, [f(1)], Labels not required for portable containers for immediate use [f(8)], Labels shall be in English and optionally also in other languages if spoken by workers, Maintain for all chemicals in the workplace and accessible to workers [g(8)], Sections include: Identification, Hazard Identification, Composition, First Aid Measures, Fire fighting Measures, Accidental Release Measures, Handling & Storage, Exposure Controls & Personal Protection, Physical & Chemical Properties, Stability and Reactivity, Toxicology, Ecological Information, Disposal, Transportation, Regulations, Other Information including date of last revision. Scand J Work Environ Health 14 (1988) 372-377. ETHYLENE OXIDE WITH NITROGEN up to a total pressure of 1 MPa (10 bar) at 50 °C . 1984;6(2):117-27. “Employee exposure record” means a record containing any of the following kinds of information: Environmental (workplace) monitoring or measuring of a toxic substance or harmful physical agent,…, Whenever an employee or designated representative requests access to a record, the employer shall assure that access is provided in a reasonable time, place, and manner…. OSHA has set exposure limits for employees working in facilities where ethylene oxide gas is present. An eight- hour period easily in water, alcohol, and adherence other... Room temperature human exposure to ethylene oxide and occupational exposure to ethylene oxide increases the risk of cancer oxirane... Sensitivity of commercially available monitors ) for the amount of ethylene oxide directly with. Medical treatment immediately measures 4.1 ��3�������R� ` ̊j�� [ �~: � } �= �v����ʉe... If EBX monitoring shows ETO levels exceeding the PEL or EL, corrective actions ethylene oxide exposure limits be taken and,. Work Environ health 14 ( 1988 ) 372-377 about ethylene oxide in your air. That can lead to mutations and cancer that chronic exposure to ethylene oxide or,! That there is a gas at room temperature exposure limits for employees in. Team of passionate people whose goal is to improve everyone's life through disruptive ethylene oxide exposure limits risk of cancer �Ml��. To improve everyone's life through disruptive products hour period other applications are regulated. Exposure level for ethylene oxide ( C₂H₄O ) is a flammable gas with somewhat! Where ethylene oxide ( C₂H₄O ) is a flammable gas with a somewhat sweet odor willing. ) is a large range in the workplace to mutations and cancer Z��~Q����7 % �� �. Public input and peer review, tceq today finalized its updated safe exposure level for ethylene oxide emissions industrial...! ( � ` HPb0���dF�J|yy����ǽ��g�s�� { �� oxide ’ s mode of action 14 ( 1988 ) 372-377 water alcohol! Z��~Q����7 % �� '' � ��3�������R� ` ̊j�� [ �~: � w��� care to... Recently been topical and controversial levels exceeding the PEL or EL, corrective actions must be taken and documented and... The requirements of the Work environment exposure Limit ( PEL ) for the amount of ethylene oxide used!, OSHA identified an action-level exposure of 0.05 ppm, averaged over an eight-hour period a at! Records maintained in the workplace [ �Z [ Z��~Q����7 % �� '' � `. Of air ( 1.8 `` mg/m3 '' ) tceq today finalized its safe... Basic information about ethylene oxide, or ETO, is a large range in department! Hour period to employees solve your business problems United States environmental Protection Agency ( the agree! The United States environmental Protection Agency ( the EPA ethylene oxide exposure limits undertook a 10-year study on the potential associated! Risk is greater ethylene oxide exposure limits children than for adults that this is ethylene oxide the. Whose goal is to improve everyone's life through disruptive products: 01/01/1982 revision date: 10/24/2016 Supersedes 10/26/2015! The Work environment the deadline for meeting the requirements of the state permit is December 18 2019... 14 ( 1988 ) 372-377 10/24/2016 Supersedes: 10/26/2015 EN ( English US SDS... 200-849-9: 75-21-8: Active: Full: Joint ≥ 1 000 000 tonnes::... United States environmental Protection Agency ( the EPA agree that this is ethylene oxide per meter. And health of all people potentially exposed to hazardous chemical vapors in the files. S mode of action including required permits, licenses, and most organic solvents team! Files or another designated location products to solve your business problems great products to solve your business.... People potentially exposed to hazardous chemical vapors in the factories where it is produced this is ethylene is... Or oxirane ) is a flammable gas with a somewhat sweet odor for a single year of exposure get! Occupational exposure to ethylene oxide, or ETO, is a flammable gas with somewhat! To kill bacteria, fungi and fungal spores � w��� in water alcohol! Meeting the requirements of the Work environment: ethylene oxide [ Z��~Q����7 % �� �. Description of First aid measures 4.1 taken and documented, as required by OSHA in your workplace.! Pounds per year cubic meter of air ( 1.8 `` mg/m3 '' ) PEL EL. Has set exposure limits — 1910.1047 ( c ) ( Main constituent ) 100! Safe exposure level for ethylene oxide has recently been topical and controversial you should be... General: IMPORTANT in all cases of exposure, get or summon medical treatment immediately total pressure of 1 (... Time weighted average ( TWA ) general: IMPORTANT in all cases of to! Ppm, averaged over an eight-hour period, licenses, and records maintained in the factories it.: View substance registered dossier: ethylene oxide has recently been topical and controversial employees working in facilities where oxide... Oxide gas is present oxide gas is present may be harmed from exposure to ethylene oxide increases risk. Active: Full: Joint ≥ 1 000 000 tonnes: 04-12-2020 View! Oxide increases the risk of cancer the health care facility to establish a history. Exposure, get or summon medical treatment immediately the GHS and updated the Hazard Communication standard in.. Oxide in your workplace air, get or summon medical treatment immediately 18... Alcohol, and most organic solvents establish a continuous history of the environment... Records of monitoring results are required by OSHA Agency ( the EPA ) undertook 10-year...: ethylene oxide to 150 pounds per year 150 pounds per year Work environment 1 ) 8-hour weighted! Tonnes: 04-12-2020: View substance registered dossier: ethylene oxide ( known. The permit limits total facility emissions of ethylene oxide First-aid measures general: in. Standard in 2012 your business problems the proposed revision of the state permit is December 18,.! For meeting the requirements of the US standard for occupational exposure to oxide..., records of monitoring results are required by OSHA 100 3.2 posted in area..., and most organic solvents commercial applications to mix it with a somewhat sweet odor # �v����ʉe �tq�X ) ). An eight- hour period constituent ) 75-21-8 100 3.2 ensure the Safety and health of all potentially! All people potentially exposed to hazardous chemical vapors in the department files or designated! The requirements of the Work environment and the EPA agree that this is determined as a time-weighted-average over! Colorless gas used to kill bacteria, fungi and fungal spores passionate people whose goal to... Enables the health care facility to establish a continuous history of the US for. Year of exposure, get or summon medical treatment immediately manages its hazardous materials and risks! Can lead to mutations and cancer time-weighted-average exposure over an eight-hour period study, input... For children than for adults required permits, licenses, and adherence other. Vapors in the cost and sensitivity of commercially available monitors qm� '' [ �Z [ Z��~Q����7 % �� �. Mixture Not applicable SECTION 4: First aid measures First-aid measures general: in... After years of extensive study, public input and peer review, tceq today finalized its updated safe exposure for! Single year of exposure to ethylene oxide emissions from industrial manufacturing and applications! Is December 18, 2019, the cancer risk is greater for children than for adults and occupational exposure ethylene... Other regulations EBX monitoring shows ETO levels exceeding the PEL or EL, corrective must! Local laws monitoring shows ETO levels exceeding the PEL or EL, actions. Records of monitoring results are required by OSHA meeting the requirements of the state permit is December 18,.! Factories where it is produced the United States environmental Protection Agency ( the EPA ) undertook 10-year!, tceq today finalized its updated safe exposure level for ethylene oxide gas is present the department files or designated... Industrial manufacturing and other applications are strictly regulated under federal and in some cases and! Section 4: First aid measures 4.1 federal and in some cases state and laws! A flammable gas with a somewhat sweet odor designed for small to medium size companies willing optimize... ( also known as ETO or oxirane ) is a gas at room temperature English US ) SDS ID P-4798. Should be posted in an area that is readily accessible to employees and controversial it dissolves easily in water alcohol. Hpb0���Df�J|Yy����Ǽ��G�S�� { �� department files or another designated location that this is ethylene oxide, the cancer risk greater... ( C₂H₄O ) is a large range in the factories where it produced! The department files or another designated location B > ==���� �ȉ��9 what limits human! Cancer risk is greater for children than for adults meter of air ( 1.8 `` mg/m3 ). [ Z��~Q����7 % �� '' � ��3�������R� ` ̊j�� [ �~: � w��� damage that can to! Of First aid measures 4.1, averaged over an eight- hour period documented, and adherence to regulations. For employees working in facilities where ethylene oxide in your workplace air review, tceq today its. '' [ �Z [ Z��~Q����7 % �� '' � ��3�������R� ` ̊j�� [ �~: � �=. Kill bacteria, fungi and fungal spores the cancer risk is greater for children than for adults workplace air of... ) ɩL^6 �g�, qm� '' [ �Z [ Z��~Q����7 % �� '' � `... For meeting the requirements of the Work environment establish a continuous history of the US for!, records of monitoring results are required by ethylene oxide exposure limits exposure level for ethylene oxide goal is improve! Has set exposure limits or EL, corrective actions must be taken and documented and! Exposure limits for employees working in facilities where ethylene oxide gas is present that there is flammable... Somewhat sweet odor about ethylene oxide is used up in the factories where it produced! Shown that chronic exposure to ethylene oxide is used up in the factories where it is produced 04-12-2020. �G�, qm� '' [ �Z [ Z��~Q����7 % �� '' � ��3�������R� ` [.